Product ID:SPRAY-MATE GLOSS BLACK, 0190WZ
MSDS Date:03/15/1996
FSC:8010
NIIN:00N072158
MSDS Number: CBXQX

ZYNOLYTE PRODUCTS CO

2320 EAST DOMINGUEZ
CARSON, CA 90749
US

Emergency Phone: 303-623-5716;800-424-9300(CHEMTREC)

Info Phone: 310-513-0700

Preparer: JOHN R KORDOSH

Cage: 25461

ZYNOLYTE PRODUCTS CO

6244 CARSON, CA 90749 US

Telephone: 310-513-0700

Cage: 25461

184 @ 68F

CAS: 67-64-1

RTECS: AL3150000

Fraction By Weight: 28%

OSHA PEL 1000 PPM

ACGIH TLV: 750PPM/1000STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

15 @

CAS: 64742-89-8

Fraction By Weight: 18%

OSHA PEL 300 PPM (MFR)

ACGIH TLV: 300 PPM (MFR)

200 @ 100F

CAS: 74-98-6

RTECS: TX2275000

Fraction By Weight: 15%

OSHA PEL 1000 PPM

ACGIH TLV: ASPHYXIANT

37 @ 100F

CAS: 106-97-8

RTECS: EJ4200000

Fraction By Weight: 11%

OSHA PEL 800 PPM

ACGIH TLV: 800 PPM

22 @ 68F

CAS: 108-88-3

RTECS: XS5250000

Fraction By Weight: 10%

OSHA PEL 200 PPM

ACGIH TLV: 50 PPM, S

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

72 @ 100F

CAS: 75-28-5

RTECS: TZ4300000

Fraction By Weight: 5%

OSHA PEL 1000 PPM (MFR)

ACGIH TLV: 800 PPM (MFR)

5.2 @

CAS: 64742-94-5

RTECS: WF3100000

Fraction By Weight: 3%

OSHA PEL 100 PPM (MFR)

ACGIH TLV: N/K

2 @ 68F

CAS: 8052-41-3

RTECS: WJ8925000

Fraction By Weight: 1%

OSHA PEL 500 PPM

ACGIH TLV: 100 PPM

KIDNEY DMG & KIDNEY/LIVER TUMORS. SEVERAL STUDIES

RTECS: 9999999ZZ

INCR OF KIDNEY DMG/INCR IN KIDNEY/LIVER TUMORS.

RTECS: 9999999ZZ

SEEK CONSULT FROM APPROP HLTH PROFESSIONALS

RTECS: 9999999ZZ

INTENTIONAL MISUSE BY DELIBERATELY

RTECS: 9999999ZZ

DO NOT SAND, FLAME CUT, BRAZE/WELD DRY COATING

RTECS: 9999999ZZ

FOLLOW THE RESPIRATOR MANUFACTURER'S DIRECTIONS

RTECS: 9999999ZZ

USE ONLY EXPLOSION-PROOF EQUIPMENT WITH

RTECS: 9999999ZZ

OF CLEANUP. APRON, COVERALLS,

RTECS: 9999999ZZ

DO NOT REUSE CLOTHING OR SHOES WHILE

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHAL: MAY CAUSE NOSE & THROAT
IRRIT. MAY CAUSE NERV SYS DEPRESS (HDCH, DIZZ, NAUS, STAG GAIT,
LASS, LOSS OF COORD, CONFUSN, UNCON). SKIN: RPTD/PRLNG LIQ CONT MAY
CAUSE IRRIT W/DISCOMFORT & DER M. EYES: MAY CAUSE IRRIT/BURNING.
EYE WATERING, HDCH, NAUS, DIZZ, ETC, ARE SIGNS THAT SOLV LEVELS ARE
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: TOO HIGH. SKIN ABSORPTION: SEE INHAL.
ORG SOLV ARE EASILY ABSORBED. DRY SKIN, REDNESS/DERM DUE TO DEFAT
ACTION OF SOLV ARE SIGNS OF EXPOS. INGEST: SEE INHAL. MAY ALSO RSLT
IN GI DISTRESS. TH ERE IS DANGER OF PETRO DISTIL ENTERING LUNGS IF
SWALLOWED/VOMITED & CAUSING INFLAMM, DMG/EVEN DEATH. (SUP DAT)
Medical Cond Aggravated by Exposure:PREEXISTING EYE, SKIN, AND
RESPIRATORY DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS
PRODUCT.

First Aid:INHAL: REMOVE TO FRESH AIR. IF NOT BRTHG, GIVE ARTF RESP,
PREF MOUTH-TO-MOUTH. CALL MD. EYES: IMMED FLUSH W/PLENTY OF WATER
FOR AT LEAST 15 MIN. CALL MD. SKIN: WASH W/SOAP & WATER. IF IRRIT
OCCURS, CO NT MD. INGEST: CALL MD IMMED. HAVE NAMES OF HAZ INGS
READY, DO NOT INDUCE VOMIT. KEEP HEAD LOWER THAN WAIST. ASPIR OF
VOMITUS MAY RSLT IN CHEM PNEUMONITIS AND/OR PULMONARY EDEMA.

Flash Point Method:TCC
Flash Point:-256F,-160C
Lower Limits:1%
Upper Limits:13%
Extinguishing Media:USE FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . AVOID CONFINED SPACES. WATER MAY BE UNSUITABLE AS AN
EXTINGUISHING MEDIUM.
Unusual Fire/Explosion Hazard:VAPS ARE HVR/AIR & MAY ACCUM IN LOW AREAS
OF POOR VENT/TRAVEL ALONG GROUND TO REMOTE IGNIT SITES. CONTENTS
ARE UNDER PRESS. KEEP COOL. EXPOS TO HEAT/ (SUP DAT)

Spill Release Procedures:ISOLATE AREA. REMOVE SOURCES OF IGNITION.
INCLUDING HOT METAL SURFACES. WEAR APPROPRIATE CLOTHING AND GEAR.
PREVENT SKIN CONTACT. AVOID BREATHING OF VAPOR. CONFINE IMMEDIATELY
AND REMOVE WITH INERT AB SORBENT SUCH AS CLAY OR SAND.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:OBSERVE LABEL PREC. KEEP AWAY FROM
HEAT, SPARKS, & OPEN FLAME (I.E., ALL IGNIT SOURCES). CAP CONTR
AFTER EACH USE. DO NOT STORE ABOVE 120F.
Other Precautions:STORE IN DRY, WELL-VENTD PLACE. DO NOT EXPOSE TO
DIRECT SUNLIGHT TO AVOID BURSTING. DO NOT SPRAY NEAR FIRE/FLAME.
AVOID UNNEC CONT. DO NOT TAKE INTERNALLY. DO NOT PUNCTURE CONTRS.
USE W/ADEQ VENT. DO NOT INHALE VAPS. (ING 13)

Respiratory Protection:DO NOT BREATHE VAPS/MISTS. IF TLV, PEL/OTHER LIM
ARE EXCEEDED, THEN WEAR PROPERLY FITTED VAP & PARTICULATE/POS PRESS
AIR SUPP RESP APPRVD BY NIOSH FOR USE W/PAINTS DURING APPLICATION &
UNTIL ALL VAPS & SPRAY MISTS ARE EXHAUSTED. (ING 15)
Ventilation:PROVIDE SUFFICIENT VENT IN VOL & PATTERN TO KEEP
CONTAMINANTS BELOW APPLIC OSHA REQS/OTHER SUGGESTED EXPOS LIM. (ING
16)
Protective Gloves:NEOPRENE GLOVES OR BETTER.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGS .
Other Protective Equipment:ANSI APPRVD EMER EYEWASH & DELUGE SHOWER .
PROTECTIVE CREAMS ARE NOT RECOMMENDED BUT MAY BE USED FOR EASE (ING
17)
Work Hygienic Practices:WASH THORO AFTER HNDLG & BEFORE EATING/SMKNG.
CHANGE CLOTHES & SHOES IN CASE OF SPILL, SPLASH/EXCESS OVERSPRAY.
(ING 18)
Supplemental Safety and Health
EXPLO HAZ: SUNLIGHT MAY CAUSE CANS TO BURST & PROPELL CONTENTS. WATER
FROM FOG NOZZ MAY BE HELPFUL IN COOLING UNRUPTURED CONTRS TO PVNT
PRESS BUILD-UP. EFTS OF OVEREXP: CHRONIC: RPTS HAVE ASSOC RPTD &
PRLNG OVEREXP TO SOLV W/PERM BRAIN & NERV SYS DMG. LAB STUDIES
W/RATS HAVE SHOWN THAT PETRO DISTIL CAUSE (ING 10)

Boiling Pt:B.P. Text:>-43F,>-42C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:0.70 (H*2O=1)
VOC Grams/Liter:5.
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:AEROSOL CAN

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ACIDS AND BASES, SELECTED AMINES.
Stability Condition to Avoid:NONE REASONABLY FORESEEABLE.
Hazardous Decomposition Products:MAY EMIT FUMES WHEN HEATED TO
DECOMPOSITION. MAY EMIT CARBON MONOXIDE, CARBON DIOXIDE,
UNIDENTIFIED ORGANIC COMPOUNDS.

Waste Disposal Methods:DO NOT ALLOW METERIAL TO CONTAMINATE GROUND
WATER SYSTEMS. PLACE IN NON-LEAKING CONTAINER. DISPOSE OF ABSORBED
MATERIAL IN ACCORDANCE WITH ALL FEDERAL, STATE, AND LOCAL
REQUIREMENTS. DO NOT INCINERATE IN CLOSED CONTAINERS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.